XCOR EZ-Rocket

The XCOR EZ-Rocket was a test platform for the XCOR XR-4A3 rocket propulsion system. The airplane was a modified Rutan Long-EZ, with the propeller replaced by first one, then later a pair of pressure-fed regeneratively cooled liquid-fueled rocket engines and an underslung fuel tank. The engines were restartable in flight, and were contained within Kevlar armor shielding. The EZ-Rocket was registered as an experimental aircraft.

The first flight took place on July 21, 2001, flown by test pilot Dick Rutan.^[1]

On a typical flight, the EZ-Rocket took off on rockets, gained altitude for a minute or so, then switched off the rockets and glided to a dead stick landing.

The vehicle actually flew better during dead stick landings than a standard Long-EZ due to lack of drag from a stationary pusher propeller — the vehicle's aerodynamics were cleaner in spite of its belly tank. It was also lighter due to the lack of a piston engine (the rocket propulsion system was significantly lighter), so enjoyed significantly lower wing loading than a standard Long-EZ.

When XCOR began flying its EZ-Rocket in 2001, the company decided to have it FAA certified as an experimental aircraft, avoiding the additional time required to seek a launch vehicle license from the Office of Commercial Space Transportation (AST). Jeff Greason, a co-founder of XCOR, said on February 10, 2003 if they were starting out at that time they probably would seek an AST license due to the progress made in developing a regulatory regime for suborbitals.^[2]

• October 8, 2000 — First firing of an XCOR Aerospace LOX-powered rocket engine.^[3]
• July 21, 2001 — First flight, flown by Dick Rutan (single-engine configuration).^[3]
• October 3, 2001 — First flight in twin-engine configuration.^[3]
• January 24, 2002 — First rocketplane inflight engine relight. Piloted by Mike Melvill.
• June 24, 2002 — First touch-and-go of a rocket-powered aircraft (world record).^[3]
• Jul 11, 2002 — EZ-Rocket flies twice in one day. First same day rocketplane flights since 1945.
• July 25, 2002 — EZ-Rocket first Oshkosh flight at the 2002 EAA AirVenture Oshkosh air show. First rocketplane air show flight in the United States.
• July 27, 2002 — EZ-Rocket second Oshkosh flight at the 2002 EAA AirVenture Oshkosh air show. Second rocketplane air show flight in the United States.
• August 26, 2005 — EZ-Rocket requalification flight after three-year retirement. Piloted by Dick Rutan.
• August 29, 2005 — Searfoss qualification flight.
• September 1, 2005 — Altitude validation flight to 11,546 feet. Aircraft demonstrated sufficient range to fly from Mojave to California City and back without a relight, a prerequisite for the world record flight.
• October 9, 2005 — EZ-Rocket second and third Las Cruces flights, at Countdown to X PRIZE Cup. Third and fourth rocketplane air show flights in the United States.
• December 3, 2005 — Set the point-to-point distance record for a ground-launched, rocket-powered aircraft, flying 16 km from Mojave to California City in just under ten minutes, piloted by Dick Rutan.^[4][5] Also first official delivery of U.S. Mail by a rocket-powered aircraft.^[4] In recognition of this achievement, the FAI awarded Rutan the 2005 Louis Blériot Medal.^[6]
• December 15, 2005 — First cross-country return flight of a rocket-powered aircraft in the United States, return flight from California City, piloted by Rick Searfoss.^[4]

The Rocket Racing League aircraft currently^[when?] in development, the Mark-III X-racer, is a design descendant of the EZ-Rocket aircraft. Although XCOR is not the developer of the rocket engine for the Mark-III, XCOR did develop the rocket engine for the Mark-I X-Racer, the first of the X-Racers to use a single rocket engine on a Velocity SE basic airframe, and the first X-Racer to utilize kerosene instead of isopropyl alcohol fuel. XCOR used both design and operational experience from the EZ-Rocket in the Mark-I rocket aircraft design.^{[citation needed]}

• Two XR-4A3 400 lbf (1.8 kN) thrust rocket engines (non throttleable, restartable in flight)^[7]
• 20 sec 500 m takeoff roll
• Vne = 200 kn (370 km/h)
• climb rate = 52 m/s (10,000 ft/min)
• maximum altitude = 11,546 ft (3,519 m) MSL
• Fuel: isopropyl alcohol and liquid oxygen
• Chamber pressure: ~ 350 psi (2.4 MPa)
• Specific impulse: 250 seconds (2.5 km/s) to 270 seconds (2.6 km/s)^{[citation needed]}
• Noise: 128 dB at 10 meters^[8]

• Messerschmitt Me 163 Komet

Wikimedia Commons has media related to XCOR EZ-Rocket.

• The EZ-Rocket (XCOR)
• howstuffworks: How the EZ-Rocket Works
• Rocket Racing League Archived 2016-03-03 at the Wayback Machine
• XCOR First Flights from Mojave Virtual Museum